Bmw K75 Gas Tank Removal

This video shows the process of how to remove / extract the fuel tank a 1990 BMW k75. Other videos related to repair and maintenance operations of the BMW K75 you see. Do not have to pull tank to change fuel filter.

It is done through filler hole from the top. Remove filler cap assembly and you can see condition of inside of tank. Backfiring is normal on a k75.

Join motobrick.com forum. The BMW part name for the cup (red item above) is "air accumulator" and it's part number is 16132307467. The drain hose (green item above) is part 16131455350.

Gas draining into the cup is why you might get a faint whiff of gas after filling up on a hot day. 6) Removing the fuel lines: (Remember that there may be pressure in the fuel system.) The fuel lines attach under the front left of the. Gas Tank Removal K75S Tank Removal By: Bryan Lally August 1995 (Editor's Note: K100 info below) I need to remove the gas tank to my '92 K75S; however the Haynes manual is less than descriptive for this model.

The manual describes two clips at the rear but where else is the thing attached? The rear of the tank has 2 pins that go through mounting holes in the frame, circlips on the posts need to be removed. Lift up the back of the tank, remove the 2 fuel hoses and 1 vent hose,lift off.

87 K75S Gas Tank RemovalGrommets should not be that tight I always smear a bit of rubber grease on the part the tank pin goes through. On the K75s depending on fuel load hitting a speed bump or a decent bump can cause the back end of the tank to jump up. This could release your side covers allowing them to make a bid for freedom.

Fitting the "C" clips with a small cable tie (not my idea. have had both a K75 (older than yours) & a K11 (newer than yours), both tanks off frequently. remember to disconnect the fuel pump wiring (has a quik-clip), and the fuel lines on left side of tank.

that's it. no need to plug ports if you're careful where you sit the tank (plastic milk crate works real well). i'd put a towel underneath it as a.

I need to remove the gas tank to my '92 K75S; however the Haynes manual is less than descriptive for this model. The manual describes two clips at the rear but where else is the thing attached? As far as the hoses go, do I need to watch for anything specific when removing or replacing the tank? Four part series of the cleaning and replacement of a K75s fuel tank innards.

K75RT Fuel Tank RemovalFlushing/changing the coolant, need access, so removing the fuel tank to get to rad cap. My two other K75's were both standard models, so no fairing. I removed the fuel tank, easily, several times.

But the RT's a bit more complicated. I can't see the lines on the left corner, because of the fairing I can't get to the side as I could on the standard, and not sure how I.